二维码（扫一下试试看！） | | 电动车辆驾驶室隔振系统建模与振动特性分析 | | Modeling and Vibration Characteristic Analysis of Cab Isolation System for Electric Driving Vehicle | | 投稿时间：2018-06-12 | | DOI：10.15918/j.tbit1001-0645.2018.增刊1.048 | | 中文关键词:驾驶室晃动模态分析液阻型橡胶隔振器驾驶室舒适性 | | English Keywords:cab vibrationmodal analysishydraulically damped rubber mountcab comfort | | 基金项目:国家自然科学基金资助项目（11472180，11572207） | | | 摘要点击次数:691 | | 全文下载次数:560 | | 中文摘要: | | 针对电动车辆驾驶室的低频振动问题，首先建立了底部装有4个隔振器的驾驶室有限元模型，提出采用三个方向的非线性弹簧阻尼单元的方法来等效替代隔振器，并进行约束模态分析.根据模态分析结果，讨论了驾驶室晃动产生的原因，并在此基础上，给出了两种减小驾驶室晃动的隔振器设计改进方法.根据实际使用情况，对液阻型橡胶隔振器进行了设计和静力分析，改善驾驶室的乘坐舒适性，此外通过调整隔振器的安装位置有效地减轻驾驶室的振动，模态分析结果显示振型频率均有所提高，同时第4阶振型变为驾驶室后壁局部振动.最后，利用有限元仿真，对驾驶室隔振系统进行振动分析，结果表明调整隔振器安装位置后的驾驶室减振系统在低频路面位移激励下垂向振幅明显减小. | | English Summary: | | To solve the problem of low frequency vibration in the cab of electric vehicle, a finite element model of cab with four isolators was established, and the nonlinear spring damping element in three directions was proposed to replace the vibration isolators. The constrained modal analysis was carried out. According to the results of modal analysis, the causes of cab shaking were discussed, and on this basis, two methods were presented to improve the vibration isolator design and reduce cab shaking. Considering the actual application condition, a hydraulic damping rubber isolator was designed and analyzed to improve the ride comfort of the cab. In addition, the installation position of the isolator was adjusted to reduce the vibration of the cab effectively. Modal analysis results show that the frequencies of the modes are increased, and the fourth order vibration mode can be transformed to the local vibration of the rear wall of the cab. Finally, the vibration analysis of cab isolation system was carried out based on finite element simulation. The results show that the vertical amplitude of cab vibration isolation system under low frequency pavement displacement excitation is obviously reduced after adjusting the installation position of the isolator. | | 查看全文查看/发表评论下载PDF阅读器 | |
章艳,娄文忠,廖茂浩,付胜华.云爆弹固体燃料云雾浓度快速检测系统设计[J].北京理工大学学报（自然科学版）,2018,38(S2):134~138.ZHANYYan,LOUWen-zhong,LIAOMao-hao,FUSheng-hua.DesignoftheFAESolidFuelCloudCo ... 北京理工大学科研学术 本站小编 Free考研考试 2021-12-21李炳沂,谢宜壮,杜青,陈禾,杨晨.SAR实时成像系统的快速定点仿真验证技术[J].北京理工大学学报（自然科学版）,2017,37(1):67~70,76.LIBing-yi,XIEYi-zhuang,DUQing,CHENHe,YANGChen.FastFixed-PointSimulationTe ... 北京理工大学科研学术 本站小编 Free考研考试 2021-12-21薛茜男,戈立军,陶进,李月,赵鹤.基于IEEE802.15.3c的OFDM超宽带系统时频同步算法[J].北京理工大学学报（自然科学版）,2017,37(1):77~82,92.XUEQian-nan,GELi-jun,TAOJin,LIYue,ZHAOHe.TimeandFrequencySynch ... 北京理工大学科研学术 本站小编 Free考研考试 2021-12-21梁士栋,赵淑芝,马明辉,刘华胜,卢春秀.路段上游直线式公交站点对车辆延误影响分析[J].北京理工大学学报（自然科学版）,2017,37(3):267~273.LIANGShi-dong,ZHAOShu-zhi,MAMing-hui,LIUHua-sheng,LUChun-xiu.TheImpacts ... 北京理工大学科研学术 本站小编 Free考研考试 2021-12-21高飞,梅力丹,潘红云,薛艳明.MIMO-OFDM系统中基于RAMP及其改进的稀疏信道估计算法[J].北京理工大学学报（自然科学版）,2017,37(3):297~303.GAOFei,MEILi-dan,PANHong-yun,XUEYan-ming.RAMPandAnImprovedAlgorit ... 北京理工大学科研学术 本站小编 Free考研考试 2021-12-21费泽松,肖玲玲,刘婷.基于LTE系统的巨量机器类通信性能分析[J].北京理工大学学报（自然科学版）,2017,37(3):304~309.FEIZe-song,XIAOLing-ling,LIUTing.MassiveMachine-TypeCommunicationPerformanceAnaly ... 北京理工大学科研学术 本站小编 Free考研考试 2021-12-21单纯,荆高鹏,胡昌振,薛静锋,贺津朝.基于漏洞知识库的8031单片机系统软件漏洞检测算法[J].北京理工大学学报（自然科学版）,2017,37(4):371~375.SHANChun,JINGGao-peng,HUChang-zhen,XUEJing-feng,HEJin-zhao.8031Micr ... 北京理工大学科研学术 本站小编 Free考研考试 2021-12-21赵红梅,吴维,胡纪滨,苑士华,狄崇峰.液压变压器控马达系统特性研究[J].北京理工大学学报（自然科学版）,2017,37(5):441~445.ZHAOHong-mei,WUWei,HUJi-bin,YUANShi-hua,DIChong-feng.CharacteristicsofHydrauli ... 北京理工大学科研学术 本站小编 Free考研考试 2021-12-21张琳,曾小华,郭孔辉,王杨,张策,宋大凤.功率分流式混合动力汽车复合电源系统设计[J].北京理工大学学报（自然科学版）,2017,37(5):478~484.ZHANGLin,ZENGXiao-hua,GuoKong-hui,WANGYang,ZHANGCe,SONGDa-feng.Designof ... 北京理工大学科研学术 本站小编 Free考研考试 2021-12-21金辉,周敏,李世杰.基于瞬态修正的车辆燃油消耗模型建模[J].北京理工大学学报（自然科学版）,2017,37(5):473~477,484.JINHui,ZHOUMin,LIShi-jie.TransientFuelConsumptionModellingBasedonTransientCorrec ... 北京理工大学科研学术 本站小编 Free考研考试 2021-12-21
| |
