删除或更新信息，请邮件至freekaoyan#163.com(#换成@)

流固耦合对油底壳振-声特性的影响研究

本站小编 Free考研考试/2021-12-21
本文二维码信息
二维码（扫一下试试看！）
流固耦合对油底壳振-声特性的影响研究
The Fluid-Structure Interaction Influence on the Vibro-Acoustic Characteristics of the Oil Pan
投稿时间：2015-07-27
DOI：10.15918/j.tbit1001-0645.2017.01.008
中文关键词:流固耦合湿模态瑞利阻尼振动响应声辐射效率
English Keywords:fluid-structure interactionwet modeRayleigh dampingvibration responsenoise radiation efficiency
基金项目:“十二五”国家科技支撑计划重点资助项目（2011BAE22B05）
作者单位E-mail
刘瑞骏浙江大学 能源工程学院, 浙江, 杭州 310027
郝志勇浙江大学 能源工程学院, 浙江, 杭州 310027haozy@zju.edu.cn
郑旭浙江大学 能源工程学院, 浙江, 杭州 310027
杨文英浙江大学 能源工程学院, 浙江, 杭州 310027
熊飞浙江大学 能源工程学院, 浙江, 杭州 310027
蒋洪峰浙江吉利动力总成研究院, 浙江, 宁波 315336
摘要点击次数:1254
全文下载次数:973
中文摘要:
对于复合钢板油底壳进行了自由模态、约束模态以及流固耦合下湿模态的计算与试验，较高的一致性表明耦合模型是合理的.模态对比结果说明当油底壳盛油后，模态振型出现了变化，且整体模态频率降低.使用最小二乘法拟合了盛油前后油底壳的瑞利阻尼比例系数.结果表明润滑油对于复合钢板油底壳的阻尼影响不大.采用多体动力学计算了耦合与非耦合油底壳的振动响应，在整体幅值和变化趋势上与试验值较接近.耦合模型的振动响应在整体上略低于非耦合模型，但500 Hz前的振动峰值更突出，尤其在330 Hz附近.耦合模型在峰值频率和趋势上与试验值吻合得更好.进一步通过边界元法计算了两种油底壳模型的辐射噪声，结果显示考虑耦合后油底壳辐射声功率在3 000 Hz内显著下降，仅在333 Hz处有较高的峰值.
English Summary:
Calculations and experiments of free modes, constraint modes and wet modes were proceeded for a sandwich steel plate oil pan. Their well matching results show that, a coupled model is feasible. The comparison between coupled and uncoupled modes demonstrates that the modal shapes change and the entire modal frequencies decrease when taking the oil into account. The ordinary least square method was applied to fit the Rayleigh damping scale factors of the oil pan with and without oil, which indicated that the oil could hardly affect the damping of the sandwich steel plate oil pan. The vibration responses of coupled and uncoupled models calculated by multi-body dynamic method indicate that the entire acceleration amplitude is close to the experimental one as well as the variation trend. It is shown that the entire vibration of the coupled model is weaker, and is prominent below 500 Hz, especially in the vicinity of 330 Hz. Besides, the peak frequencies and the trend of the coupled model coincide with the experimental result much better. Furthermore, the comparison of the radiation noise calculated by the boundary element method demonstrates that an evident entire decline occurs after considering the oil in the range of 0~3 000 Hz except 333 Hz.
查看全文查看/发表评论下载PDF阅读器
相关话题/浙江 能源 浙江大学 工程学院 计算

Free考研考试FreeKaoYan.Com
欢迎来到Free考研考试，"为实现人生的Free而奋斗"

© 2020 FreeKaoYan! . All rights reserved.